黄春燕,蔡小舒,苏明旭

• 1:上海理工大学能源与动力工程学院
• 2:上海理工大学学报编辑部

摘要(Abstract)：

在玻璃微珠-水两相搅拌体系中,利用宽带声发射传感器高速采集声发射信号,选择Db8小波基函数对信号进行10层分解,提取各尺度信号能量及能量占比等特征量,研究了特征量随搅拌速度、测量点位置、玻璃微珠质量和粒径的变化规律。结果表明,由玻璃微珠碰撞内壁面造成的声发射信号能量主要集中在D7~D10等四个尺度;随玻璃微珠质量增加,多测量点各尺度信号能量值较单测量点值显示出更良好的线性关系,且不同粒径下的能量占比特征量均各自趋于一个较为稳定的数值范围,可用来表征粒径变化的规律性。实验结果为后续利用声发射信号测量多颗粒系粒径提供了的实验依据。

关键词(KeyWords)： 声发射;多尺度;特征分析;粒径

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金重点项目(50836003,51176128)

作者(Author): 黄春燕,蔡小舒,苏明旭

参考文献(References)：

• [1]Bouchard J G,Payne P A,Szyszko S.Non-invasive measurement of process states using acoustic emission techniques coupled with advanced signal processing:Process operation and control[J].Chemical Engineering Research and Design,1994,72(1):20-25.
• [2]Whitaker M,Baker G R,Westrup J,et al.Application of acoustic emission to the monitoring and end point determination of a high shear granulation process[J].International Journal of Pharmaceutics,2000,205(1/2):79-91.
• [3]Huang J,Ose S,Silva S,et al.Non-invasive monitoring of powder breakage during pneumatic transportation using acoustic chemometrics[J].Powder Techology,2003,129:130-138.
• [4]HUANG Zheng-liang(黄正梁),WANG Jing-dai(王靖岱),YANG Yong-rong(阳永荣).Measurement of slurry concentration in stirred vessel based on AE measurement by wavelet transform(声波的多尺度分解与搅拌釜中浆液浓度的测量)[J].J Chem Ind and Eng(China)(化工学报),2006,57(9):2062-2067.
• [5]WANG Jing-dai(王靖岱),JIANG Bin-bo(蒋斌波),YANG Yong-rong(阳永荣),et al.Multi-scale analysis of acoustic emissions and malfunction diagnosis in gas-solid fluidized bed(声波的多尺度解析与气固流化床故障检测)[J].J Chem Ind and Eng(China)(化工学报),2006,57(7):1560-1564.
• [6]YANG Yong-rong(阳永荣),HOU Lin-xi(侯琳熙),WANG Jing-dai(王靖岱).The study on particle size distribution in gas-solid fluidized beds based on AE measurement(声波的多尺度分解与颗粒粒径分布的实验研究)[J].Prog Nat Sci(自然科学进展),2005,15(3):380-384.
• [7]Alison N,Yvonne C,Anthony G,et al.Factors affecting broadband acoustic emission measurements of a heterogeneous reaction[J].Analyst,2006,131:323-330.
• [8]CUI Jin-tai(崔锦泰).Introduction of wavelet analysis(小波分析导论)[M].CHENG Zheng-xing(程正兴),trans.Xi'an(西安):Xi'an Jiao Tong University Press(西安交通大学出版社),1995.
• [9]TIAN Zeng-guo(田增国),CHEN Cui-mei(陈翠梅).Acoustic emission signal processing based on wavelet analysis(基于小波分析的声发射信号处理)[J].Industrial Safety and Environmental Protection(工业安全与环保),2002,29(8):26-28.
• [10]Carson G.Particle sizing using Hertz-Zener theory and ultrasonic measurement of impact vibrations[D].Glasgow:University of Strathclyde,2008.