徐百龙,夏银锋,王向前,王俏丽,刘楠,李伟

• 1:浙江大学生物质化工教育部重点实验室
• 2:浙江大学化学工程与生物工程学院
• 3:浙江大学环境工程研究所

摘要(Abstract)：

研究了硅油对生物法处理有机废气的强化效果。在摇床实验中考察了硅油对邻二甲苯的增溶效果,及其对微生物降解活性的影响情况。结果表明硅油对邻二甲苯有明显的增溶效果且对微生物的活性无影响。在生物滴滤塔挂膜稳定后,考察了加入5%硅油后邻二甲苯在生物滴滤塔中的去除效率变化。相同实验条件下,当进气浓度在600 mg·m-3左右时,硅油可以使邻二甲苯的去除效率明显增加。研究结果显示,添加硅油的生物滴滤塔在去除邻二甲苯废气方面效率更高,去除效率比普通生物滴滤塔高10%左右。根据以上实验结果可以得出结论,硅油能有效提高生物法处理邻二甲苯废气的效果。

关键词(KeyWords)： 硅油;生物滴滤塔;有机废气;邻二甲苯

Abstract:

Keywords:

基金项目(Foundation): 国家“863”计划项目(2012AA063102);; 浙江省科技计划项目(2009C03009-4)

作者(Author): 徐百龙,夏银锋,王向前,王俏丽,刘楠,李伟

参考文献(References)：

• [1]LI Shun-yi(李顺义),YANG Song-bo(杨松波),LI Hong-li(李红丽),et al.Study on the treatment of ammonia-contaminated gas by biofiltration with corn-cob packing(玉米芯填料生物过滤法净化含氨废气研究)[J].J Chem Eng of Chinese Univ(高校化学工程学报),2011,25(2):351-355.
• [2]Munoz R,Villaverde S,Guieysse B,et al.Two-phase partitioning bioreactors for treatment of volatile organic compounds[J].Biotechnology Advances,2007,25(4):410-422.
• [3]Van Groenestijn J W,Lake M E.Elimination of alkanes from off gases using biotrickling filters containing two liquid phases[J].Environmental Progress,1999,18(3):151-155.
• [4]Bailon L,Nikolauszb M,Kastnerb M,et al.Removal of dichloromethane from waste gases in one-and two-liquid-phase stirred tank bioreactors and biotrickling filters[J].Water Research,2009,43(1):11-20.
• [5]Munoz R,Arriaga S,Hernandez S,et al.Enhanced hexane biodegradation in a two phase partitioning bioreactor:Overcoming pollutant transport limitations[J].Process Biochemsitry,2006,41(7):1614-1619.
• [6]Aldric J M,Thonart P.Performance evaluation of a water/silicone oil two-phase partitioning bioreactor using Rhodococcus erythropolis T902.1 to remove volatile organic compounds from gaseous effluents[J].Journal of Chemical Technology and Biotechnology,2008,83(10):1401-1408.
• [7]Rene E R,Montes M,Veiga M C,et al.Styrene removal from polluted air in one and two-liquid phase biotrickling filter:Steady and transient-state performance and pressure drop control[J].Bioresource Technology,2011,102(13):6791-6800.
• [8]Yeom S H,Daugulis A J.Development of a novel bioreactor system for treatment of gaseous benzene[J].Biotechnology and Bioengineering,2001,72(2):156-165.
• [9]Nielsen D R,Sask K N,Mclellan P J,et al.Benzene vapor treatment using a two-phase partitioning bioscrubber:an improved steady-state protocol to enhance long-term operation[J].Bioprocess and Biosystems Engineering,2006,29(4):229-240.
• [10]Boudreaun N G,Daugulis A J.Transient performance of two phase partitioning bioreactor treating a toluene contaminated gas stream[J].Biotechnology and Bioengineering,2006,94(3):448-457.
• [11]Guieysse B,Vikund G.Sequential UV-biological degradation of polycyclic aromatic hydrocarbons in two-phases partitioning bioreactors[J].Chemosphere,2005,59(3):369-376.
• [12]Arriaga S,Munoz R,Hernandez S,et al.Gaseous hexane biodegradation by Fusarium solani in two-liquid phase packed-bed and stirred-tank bioreactors[J].Environmental Science and Technology,2006,40(7):2390-2395.
• [13]Munoz R,Chambaud M,Bordel S,et al.A systematic selection of the non-aqueous phase in a bacterial two liquid phase bioreactor treatingα-pinene[J].Applied Microbiology and Biotechnology,2008,79(1):33-41.
• [14]ZHOU Xue-xia(周学霞),YAO Guo-wei(姚伟国),YANG Bing-xue(杨冰雪),et al.Removal of o-xylene from waste gases by biotricking filter(生物滴滤塔处理邻二甲苯废气研究)[J].Journal of Zhejiang University:Science Edition(浙江大学学报(理学版)),2013,40(1):71-75.
• [15]Jeong E,Mitsuyo Hirai M,Shoda M.Removal of o-xylene using biofilter inoculated with Rhodococcus sp.BTO62[J].Journal of hazardous materials,2008,152(1):140-147.
• [16]Hartmans S,Tramper J.Dichloromethane removal from waste gases with a trickle-bed bioreactor[J].Bioprocess and Biosystems Engineering,1991,6:83-92.